Share this article

print logo

Ford, Toyota issue global recalls

Toyota and Ford recalled nearly 2.1 million vehicles worldwide Wednesday. Toyota recalled 1.7 million cars -- mostly in Japan -- for possible fuel leaks, the latest in a ballooning number of quality problems that could further tarnish the company's reputation in the United States.

Ford Motor Co. recalled more than 400,000 Windstar minivans in cold-weather states to fix brackets and mounts that could separate from the vehicle's subframe and cause a driver to lose control.

The recall, the latest quality issue to afflict older Windstars, covered 425,288 minivans from the 1999-2003 model years sold or registered in 22 states and the District of Columbia. Ford said there had been seven crashes and five minor injuries connected to the recall.

Ford has recalled more than 600,000 of the minivans in the U.S. and Canada since August to address rear axles that can corrode and break. The National Highway Traffic Safety Administration also has been investigating corrosion problems in the minivans from the 1999-2003 model years. The Transportation Department said Wednesday that the minivans were still under review by the agency.

The recall affects brackets and mounts connected to the front subframe, which carries the engine, transaxle, steering rack and front suspension. NHTSA said in a posting on its website that if the mounts separated from the frame, a driver could experience reduced steering control.

The recall is limited to states where road salt is used during the winter. They include: Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Utah, Vermont, West Virginia and Wisconsin.

Previously, NHTSA issued a consumer advisory in November asking owners to bring their vehicles to a dealership immediately to be examined for signs of rear-axle corrosion. NHTSA said then that only about 75,000 recalled minivans had been brought to dealers.

Ford said it would notify affected owners in mid-February and dealers would inspect the vehicles and install reinforcement brackets as parts become available. The company said if the vehicle does not pass inspection before parts are available, Ford would provide a rental vehicle. If a dealer determines that the front subframe cannot be repaired, the company said it would offer to buy back the minivan.

The Toyota recalls include Lexus IS and GS luxury sedans sold in North America. That's where the world's No. 1 car company faces the biggest challenges in winning back customer trust.

In one of the problems announced Wednesday, an improper installation of a sensor to measure fuel pressure may cause the device to loosen as a result of engine vibrations, and possibly cause fuel to leak, the company said. That problem also affects 280,000 Lexus cars sold abroad, most in North America.

Included under that recall are the 2006 through 2007 Lexus GS30 0/3 50, 2006 through early 2009 Lexus IS250, and 2006 through early 2008 Lexus IS350 sold in the U.S.

There are no comments - be the first to comment